The short version of Cake collapse fits in a sentence. The long version — which is the one that helps — is below.
Reviewed 2026-02-19. Anything still debated is marked as such rather than presented as settled.
After drying, a lyophilized product is usually sealed under vacuum or an inert gas to limit moisture uptake. Residual water content is measured because small changes can alter chemical stability and cake appearance. Storage temperature depends on the material; many biological products are kept at 2–8 °C, while some require −20 °C or colder. Exposure to ambient humidity during handling can cause the porous solid to absorb water and collapse. Container closures and stoppers are therefore selected for low moisture transmission and compatibility.
Quality control for lyophilized materials includes visual inspection of the cake, measurement of residual moisture, and tests for reconstitution time. An acceptable cake is typically uniform and may be slightly porous; shrinkage, meltback, or cracks can indicate process deviations. Analytical methods such as Karl Fischer titration, thermogravimetric analysis, and near-infrared spectroscopy quantify water content. Reconstitution time is recorded because a very slow or incomplete dissolution can signal collapse or aggregation. Stability studies compare samples stored under defined temperature and humidity conditions over months or years.
A typical cycle begins with freezing, which fixes the material into a solid and determines ice crystal size. Primary drying then raises heat under vacuum so ice sublimes, often near or below the collapse temperature of the formulation. Secondary drying removes bound water that remains after ice is gone, usually by gently warming the product. Each stage balances heat input against pressure to avoid melting or structural damage. Temperature probes and pressure sensors guide the transition between stages.
In practice, lyophilization is slower and more energy intensive than simple drying. Cycle times can range from hours to several days depending on load, container, and formulation. Amorphous materials may require excipients that help preserve structure during freezing and drying. The method is widely used for biological materials, pharmaceuticals, and foods where heat drying would cause unacceptable change. Open questions remain about scaling cycles between laboratory and production equipment, and this gap affects technology transfer.
Lyophilization removes water by freezing a material and then lowering pressure so ice changes directly to vapor. The process relies on sublimation, the phase transition from solid to gas without an intermediate liquid state. Because the material remains frozen during primary drying, the structure often stays porous. This porous matrix can rehydrate quickly when water is added back. The low pressure also allows vapor to leave the solid matrix without boiling.
| Property | Value | Notes |
|---|---|---|
| Typical storage temperature | 2–8 °C | Common for biological materials; some require −20 °C or colder |
| Residual moisture specification | 0.5–3.0% w/w | Product-specific; measured after drying |
| Common moisture method | Karl Fischer titration | Coulometric or volumetric; detects water content |
| Cake appearance | Uniform and porous | Collapse, meltback, or cracks are deviations |
| Reconstitution time | Seconds to several minutes | Depends on formulation, cake structure, and diluent |
Other physicians were less optimistic about the adverse effects of DNP, and in 1935 the American Medical Association's Council on Chemistry and Pharmacy declined to list DNP in the New and Nonofficial Remedies on the grounds that its benefits did not exceed its risks to health. Reports of cataracts forming during DNP usage administered by a physician appeared the same year; in 1936 an ophthalmologist based in San Francisco estimated that 2,500 American women had gone blind from DNP use. Physician opinion turned against the drug, but many people bought direct-to-consumer preparations of DNP—marketed as a cosmetic rather than a drug to evade existing regulations. DNP's risks were highlighted in the Chamber of Horrors, an exhibit assembled by the United States Food and Drug Administration (FDA) to explain the limitations of existing American drug regulations. In 1938, the Food, Drug, and Cosmetic Act increased the FDA's ability to regulate drugs. DNP was deemed so toxic as to be banned for human consumption and in 1940 the FDA reported that there was no evidence of continued sale for this purpose. Nevertheless, it continued to be used for weight loss. William F. Loomis and Fritz Albert Lipmann discovered DNP's mechanism of action and reported it in a 1948 publication. Reports of its use increased in the twenty-first century after the drug became available on the Internet.
10 October — Local authorities activate emergency operations centres in the Grey and Buller Districts in response to heavy rainfall, flooding and landslides. MetService issues heavy rain and wind warnings for that region. 11 October: The 2025 local elections, including local referendums on Māori wards and constituencies, conclude. 24 district and regional councils vote to remove their Māori wards and constituencies while 18 others vote to retain them. 14 October: Minister for Rail Winston Peters confirms that the New Zealand Government has contracted the Chinese state-owned shipyard COMEC to build two new rail-enabled Interislander ferries, which are expected to be delivered in 2029. The New Zealand Parliament passes legislation allowing radio and television stations to broadcast advertisements on Christmas Day, Good Friday, Easter Sunday and Anzac Day. Heavy rain causes flooding in the Waitomo and Ruapehu Districts in the central North Island, affecting several farms, roads, and some houses. Mayor of Waitomo John Robertson estimates the flood damage to be in the regions. 17 October: Highways reopen in the flood-stricken Waitomo and Ruapehu Districts. The New Zealand Professional Firefighters Union (NZPFU) held a one hour strike following the breakdown of pay negotiations broke down with Fire and Emergency New Zealand. The New Zealand Government reinstates several United Nations sanctions against Iran including asset freezes, travel bans and trade restrictions after Iran withdraws from the JCPOA agreements in September 2025.
== Principle of chiral column chromatography == The chiral stationary phase, CSP, can interact differently with two enantiomers, by a process known as chiral recognition. Chiral recognition depends on various interactions such as hydrogen bonding, π-π interaction, dipole stacking, inclusion complexation, steric, hydrophobic and electrostatic interaction, charge-transfer interactions, ionic interactions etc, between the analyte and the CSP, to form in-situ transient-diastereomeric complexes. Most of the types of stationary phases can be classified as Pirkle type (Brush type), Protein-based, Cyclodextrins based, Polymer-based carbohydrates (polysaccharide-based CSPs), Macrocyclic antibiotic, Chiral crown ethers, imprinted polymers, etc.
An X-ray room must be shielded on all sides with 1 mm lead equivalent shielding. Calcium silicate or solid brick masonry is recommended. A steel jamb should be used, not only because of the weight of the heavy shielding door but also because of the shielding; wooden frames must be shielded separately. The shielding door must be covered with a 1 mm thick lead foil and a lead glass window must be installed as a visual connection. A keyhole shall be avoided. All installations (sanitary or electrical), that interrupt the radiation protection, must be leaded ( § 20 § 20 Röntgenverordnung (röv_1987) [§ 20 X-ray Ordinance] (in German) and § Annex+2 Annex 2 (to § 8 para. 1 sentence 1 RöV) (röv_1987) (in German) Depending on the application, nuclear medicine requires even more extensive protective measures, up to and including concrete walls several meters thick. In addition, from December 31, 2018, when the latest amendments to Section 14 (1) No. 2b of the Radiation Protection Act § 14 Strahlenschutzgesetz – StrlSchG [Radiation Protection Act (StrlSchG)] (in German) come into force, an expert in medical physics for X-ray diagnostics and therapy must be consulted for the optimization and quality assurance of the application and for advice on radiation protection issues.
Sources: en.wikipedia.org
==== Kazakhstan ==== Institute of World Economics and Politics (IWEP) at the Foundation of the First President of the Republic of Kazakhstan was created in 2003. IWEP activities aimed at research problems of the world economy, international relations, geopolitics, security, integration and Eurasia, as well as the study of the First President of the Republic of Kazakhstan and its contribution to the establishment and strengthening of Kazakhstan as an independent state, the development of international cooperation and the promotion of peace and stability. The Kazakhstan Institute for Strategic Studies under the President of the RK (KazISS) was established by the Decree of the President of RK on 16 June 1993. Since its foundation the main mission of the Kazakhstan Institute for Strategic Studies under the President of the Republic of Kazakhstan, as a national think tank, is to maintain analytical and research support for the President of Kazakhstan.
== Historical conception == In ancient alchemy, a protoscience that contributed to the development of modern chemistry and medicine, alchemists developed a structure of basic laboratory techniques, theory, terminology, and experimental methods. Sublimation was used to refer to the process in which a substance is heated to a vapor, then immediately collects as sediment on the upper portion and neck of the heating medium (typically a retort or alembic), but can also be used to describe other similar non-laboratory transitions. It was mentioned by alchemical authors such as Basil Valentine and George Ripley, and in the Rosarium philosophorum, as a process necessary for the completion of the magnum opus. Here, the word sublimation was used to describe an exchange of "bodies" and "spirits" similar to laboratory phase transition between solids and gases. Valentine, in his Le char triomphal de l'antimoine (Triumphal Chariot of Antimony, published 1646) made a comparison to spagyrics in which a vegetable sublimation can be used to separate the spirits in wine and beer. Ripley used language more indicative of the mystical implications of sublimation, indicating that the process has a double aspect in the spiritualization of the body and the corporalizing of the spirit. He writes:
=== United Kingdom === In 2008, a herd of Wagyu cattle was imported to North Yorkshire, first becoming available for consumption in 2011. Since 2011, there have been Wagyu herds in Scotland. There are British & Irish Wagyu Fullbloods registered through the British Wagyu Breeders Association.
Sources: en.wikipedia.org
Most are held in sealed containers at controlled temperatures, often 2–8 °C, while some require frozen storage. Protection from moisture and light helps preserve the dry matrix. Exact conditions are set by the manufacturer or study protocol.
Cake collapse suggests the material exceeded its collapse temperature during drying or later absorbed moisture. It can lead to slower reconstitution, uneven moisture, and reduced stability. Appearance alone may not reveal the cause, so process records and moisture tests are used together.
Some residual moisture is common and may be acceptable within a defined range. Very low moisture can alter stability or increase brittleness, while high moisture promotes hydrolysis and microbial risk. Specifications are based on product-specific stability data.
Primary drying removes ice by sublimation under vacuum. Secondary drying removes water that is bound to the material, often by warming the product after most ice has left. Both stages occur below temperatures that would cause unwanted melting.