The short version of moisture content fits in a sentence. The long version — which is the one that helps — is below.
This page was last updated on 2026-02-01 and is reviewed periodically as new material appears.
Stability of a lyophilized product depends on its glass transition temperature, the temperature at which the amorphous cake transitions from a glassy to a rubbery state. Storage below this temperature minimizes molecular mobility and slows chemical degradation. If the storage temperature exceeds the glass transition temperature, the cake may collapse, shrink, or become sticky. Accelerated stability studies at elevated temperatures and humidity help predict shelf life, but they do not always reflect real-time behavior. Residual moisture content also plays a critical role in long-term stability.
Reconstitution involves adding a suitable diluent, often sterile water or a buffer, to the dried cake. Gentle swirling or inversion helps dissolve the material without creating excessive foam. The time required for complete dissolution can range from seconds to several minutes and depends on the cake structure and the diluent. Improper reconstitution, such as vigorous shaking or using the wrong diluent, can cause protein aggregation or loss of activity. After reconstitution, the product may have a limited shelf life and should be used according to its labeling.
In practice, lyophilization is slower and more energy intensive than simple drying. Cycle times can range from hours to several days depending on load, container, and formulation. Amorphous materials may require excipients that help preserve structure during freezing and drying. The method is widely used for biological materials, pharmaceuticals, and foods where heat drying would cause unacceptable change. Open questions remain about scaling cycles between laboratory and production equipment, and this gap affects technology transfer.
Lyophilization removes water by freezing a material and then lowering pressure so ice changes directly to vapor. The process relies on sublimation, the phase transition from solid to gas without an intermediate liquid state. Because the material remains frozen during primary drying, the structure often stays porous. This porous matrix can rehydrate quickly when water is added back. The low pressure also allows vapor to leave the solid matrix without boiling.
| Property | Value | Notes |
|---|---|---|
| Appearance | White to off-white porous cake | Color depends on formulation. |
| Typical storage temperature | 2–8 °C | Refrigerated for many biologics. |
| Residual moisture | <1% to 3% | Low moisture improves stability. |
| Container | Sealed glass vial | Often with rubber stopper and aluminum crimp. |
| Reconstitution time | Seconds to minutes | Varies with cake density and diluent. |
Quality control for freeze-dried lots combines visual inspection with instrumental tests. Cake appearance, color, and shrinkage are recorded against a reference, while residual moisture is measured by Karl Fischer titration or loss on drying. Thermal analysis can reveal phase transitions and crystallization events, and X-ray diffraction distinguishes amorphous from crystalline solids. Microbiological tests and container closure integrity checks are also routine for sterile products. Analytical methods must be validated for the matrix, because excipients and low moisture can affect accuracy. Open questions include how best to predict long-term stability from short-term data.
Lyophilized solids are often hygroscopic, so handling occurs in controlled low-humidity areas or glove boxes when the material is exposed. Vials remain sealed with elastomeric stoppers and aluminum crimps until use, because airborne moisture can raise residual water and shorten shelf life. The porous cake is fragile and may crack, shrink, or powder during transport. Personnel typically avoid repeated warming and cooling of sealed units, which can draw moisture through closures. These practices aim to preserve the low water content achieved during drying.
The physical chemistry of freezing influences whether a formulation forms an amorphous glass or a crystalline solid. Amorphous systems can collapse if product temperature rises above the glass transition temperature of the freeze concentrate. Crystalline systems may show eutectic melting, where ice and solute melt together at a fixed temperature. Formulators add bulking agents, lyoprotectants, and buffers to preserve structure and biological activity. The optimum cycle keeps product temperature below critical thresholds during primary drying while allowing efficient sublimation.
Lyophilization is a dehydration process that removes water from a frozen material by sublimation under low pressure. The material is first frozen so that water becomes ice; then the surrounding pressure is lowered below the vapor pressure of ice. Heat is applied gently so ice changes directly to vapor without passing through a bulk liquid phase. The vapor is collected on a cold condenser, leaving a dry porous matrix. This process differs from simple evaporation because the material remains frozen during the main drying stage.
The process usually has three stages: freezing, primary drying, and secondary drying. Freezing sets the ice crystal structure and can determine pore size in the final cake. Primary drying removes free ice by sublimation at low pressure and low shelf temperature. Secondary drying removes bound water by raising the shelf temperature, although some water may remain as part of the solid. Cycle parameters depend on formulation, fill volume, vial type, and equipment performance.
Analytical methods for lyophilized solids must account for the low moisture content and the fragile cake. Karl Fischer titration is widely used for water content, while near-infrared spectroscopy can measure moisture non-destructively in sealed containers. X-ray diffraction and modulated differential scanning calorimetry help identify crystalline or amorphous phases. Residual solvent analysis may be needed if organic solvents were used during formulation. The combination of these methods supports batch release and long-term stability assessment.
Lyophilized products are typically stored as sealed solids in vials or syringes. Moisture ingress is a major concern because many dried cakes are hygroscopic and can lose stability when exposed to humid air. Storage temperature depends on the formulation; some products are kept refrigerated, while others are stable at room temperature. Container closure integrity and headspace moisture are often monitored. Light protection may also be required for some photosensitive materials.
Quality control for lyophilized materials includes visual inspection, residual moisture measurement, and reconstitution testing. Cake appearance can reveal process problems such as collapse, shrinkage, or meltback, although appearance alone does not prove potency. Residual moisture is commonly measured by Karl Fischer titration or by loss on drying. Reconstitution time is checked because a slow or incomplete dissolve can indicate a change in pore structure. Stability studies track these attributes over time under defined temperature and humidity conditions.
The constriction toward the tip of the Pasteur pipettes may be plugged with a bit of tissue paper or cotton wool to filter off solids from small amounts of liquids. The bulb can be attached and squeezed to help viscous solutions filter more rapidly. With a bit of skill, Pasteur pipettes may also be used for microscale column chromatography. With appropriately fine silica gel, the bulb may be squeezed for microscale flash column chromatography.
== Match-fixing scandals == Ten of the twelve members of the gold medal-winning Spanish basketball team at the 2000 Summer Paralympics were revealed to have no disability. Fresno Case scandal (2004) – an attempt to rig a vote to prevent the Catalan rink hockey team from being accepted into international competition. Melbourne Football Club tanking scandal (2009) – allegations arose that the club deliberately lost matches in 2009 so that it would put itself into a position whereby they would secure a priority draft pick at that year's draft. In 2011, snooker player John Higgins was accused of accepting bribery in order to lose frames purposefully. Higgins denied any accusations of match-fixing and bribery, however, he was found guilty of accepting bribery while there was no evidence for him match-fixing. "World number one John Higgins has been suspended from all future tournaments after reportedly agreeing to take a £261,000 bribe to lose frames." Match fixing in tennis 1964 British football match-fixing scandal 1971 Bundesliga scandal Match-fixing investigations of Norwegian Second Division Match fixing in English football Match fixing in Romanian football
Tacrolimus and a related drug for eczema (pimecrolimus) were suspected of carrying a cancer risk, though the matter is still a subject of controversy. The FDA issued a health warning in March 2005 for the drug, based on animal models and a small number of patients. Until further human studies yield more conclusive results, the FDA recommends that users be advised of the potential risks. However, current practice by UK dermatologists is not to consider this a significant real concern and they are increasingly recommending the use of these new drugs. A 2023 systematic review and meta-analysis published in The Lancet Child & Adolescent Health concluded with moderate-certainty evidence that the two drugs were not associated with any increased risk of cancer. In November 2024, International Agency for Research on Cancer (IARC) classified hydrochlorothiazide, voriconazole and tacrolimus as group 1 carcinogens.
=== 1984 === January: U.S. President Ronald Reagan outlines foreign policy which reinforces his previous statements. January 1: Brunei gains independence from the UK. February 13: Konstantin Chernenko is named General Secretary of the Soviet Communist Party. May 24: the U.S. Congress ratifies the Boland Amendment banning U.S. aid to the contras. June 1–10: Operation Blue Star begins. July 28: various allies of the Soviet Union boycott the 1984 Summer Olympics (July 28 – August 12) in Los Angeles. August 11: during a microphone sound check for his weekly radio address, President Ronald Reagan jokes about bombing the Soviet Union. "My fellow Americans", Reagan says. "I'm pleased to tell you today that I've signed legislation that will outlaw Russia forever. We begin bombing in five minutes." The quip is not aired but is leaked to the press. The Soviet Union temporarily puts its defense forces on high alert. October 19: Father Jerzy Popiełuszko assassinated. October 31: Indira Gandhi assassinated. December 16: Margaret Thatcher and the UK government, in a plan to open new channels of dialog with Soviet leadership candidates, meet with Mikhail Gorbachev at Chequers.
== Board of directors == The board of directors is composed of thirteen members, in office until the approval of the financial statements at 31 December 2020, with Alberto Vacchi in the role of chairman and executive CEO. Marco Vacchi is the honorary president.
Sources: en.wikipedia.org
Only 10 to 15% of tumours are suitable for surgical resection. As of 2018, when chemotherapy is given the FOLFIRINOX regimen containing fluorouracil, irinotecan, oxaliplatin and leucovorin has been shown to extend survival beyond traditional gemcitabine regimens. For the most part, treatment is palliative, focusing on the management of symptoms that develop. This may include management of itch, a choledochojejunostomy, or the insertion of stents with ERCP to facilitate the drainage of bile, and medications to help control pain. In the United States, pancreatic cancer is the fourth most common cause of death due to cancer. The disease occurs more often in the developed world, which had 68% of new cases in 2012. Pancreatic adenocarcinoma typically has poor outcomes, with the average percentage alive for at least one and five years after diagnosis being 25% and 5% respectively. In localized disease where the cancer is small (< 2 cm) the number alive at five years is approximately 20%. There are several types of pancreatic cancer, involving both the endocrine and exocrine tissue. The many types of pancreatic endocrine tumors are all uncommon or rare, and have varied outlooks. However, the incidence of these cancers has been rising sharply; it is not clear to what extent this reflects increased detection, especially through medical imaging, of tumors that would be very slow to develop. Insulinomas (largely benign) and gastrinomas are the most common types.
A small portion of approximately 3% of testosterone is reversibly converted in the liver into androstenedione by 17β-HSD. In addition to conjugation and the 17-ketosteroid pathway, testosterone can also be hydroxylated and oxidized in the liver by cytochrome P450 enzymes, including CYP3A4, CYP3A5, CYP2C9, CYP2C19, and CYP2D6. 6β-Hydroxylation and to a lesser extent 16β-hydroxylation are the major transformations. The 6β-hydroxylation of testosterone is catalyzed mainly by CYP3A4 and to a lesser extent CYP3A5 and is responsible for 75 to 80% of cytochrome P450-mediated testosterone metabolism. In addition to 6β- and 16β-hydroxytestosterone, 1β-, 2α/β-, 11β-, and 15β-hydroxytestosterone are also formed as minor metabolites. Certain cytochrome P450 enzymes such as CYP2C9 and CYP2C19 can also oxidize testosterone at the C17 position to form androstenedione. Two of the immediate metabolites of testosterone, 5α-DHT and estradiol, are biologically important and can be formed both in the liver and in extrahepatic tissues. Approximately 5 to 7% of testosterone is converted by 5α-reductase into 5α-DHT, with circulating levels of 5α-DHT about 10% of those of testosterone, and approximately 0.3% of testosterone is converted into estradiol by aromatase. 5α-Reductase is highly expressed in the male reproductive organs (including the prostate gland, seminal vesicles, and epididymides), skin, hair follicles, and brain and aromatase is highly expressed in adipose tissue, bone, and the brain.
The Ministry also indicated it had captured 4 of the Comandos de la Frontera, who were later released. The United States Department of Defense, did not comment as an investigation into the event is ongoing, but referred the matter to the Office of the Director of National Intelligence for further questions. In January 2026, an Ecuadorian fishing vessel, carrying eight crew members disappeared, while two other crew member were away. When they returned to the boat's last know location, there was no sign of it and it is unknown what happened to it. In March, two Ecuadorian fishing vessels near the Galápagos Islands in Ecuador's exclusive economic zone were attacked and damaged by small, explosive-laden rotor drones. In both these incidents, the crews reported being later taken aboard a U.S. military vessel and later transferred to El Salvador and handed over to the authorities there, before being returned to Ecuador. The Washington Post reported in August that the two Galápagos boat strikes were part of a covert CIA program, although CNN said they could not independently verify this. While the US has admitted attacking dozens of alleged drug-trafficking vessels in the Caribbean and Pacific, they have denied responsibility for these incidents. Ecuadorian authorities have also largely not commented on them. In late August, the U.S., in collaboration with Ecuador, began sinking Ecuadorian vessels alleged to be involved drug traffickiing. Within two weeks, six vessels were sunk, with the crews being removed and transferred to Ecuadorian authorities before the boats were sunk.
== Function == CGRP is produced in both peripheral and central neurons. It is a potent peptide vasodilator and can function in the transmission of nociception. In the spinal cord, the function and expression of CGRP may differ depending on the location of synthesis. CGRP is derived mainly from the cell bodies of motor neurons when synthesized in the ventral horn of the spinal cord and may contribute to the regeneration of nervous tissue after injury. Conversely, CGRP is derived from dorsal root ganglion when synthesized in the dorsal horn of the spinal cord and may be linked to the transmission of pain. In the trigeminal vascular system, the cell bodies of the trigeminal ganglion are the main source of CGRP. CGRP is thought to play a role in cardiovascular homeostasis and nociception. In the heart, CGRP acts as a chronotrope by increasing heart rate. Apart from these attributes, CGRP is known to modulate the autonomic nervous system and plays a role in ingestion. CGRP has moderate effects on calcium homeostasis compared to its extensive actions in other areas, such as the autonomic nervous system.
In September 2019, Collins released her debut perfume, Diva Pink. The unisex fragrance has a guaiac wood, saffron, rose and sandalwood scent, and is described as a "sensual fragrance with luxury oud and diva day undertones". Collins has also launched two lipsticks, "Candy" and "Diva" as well as her own range of false eyelashes. In March 2020, Collins announced her collaboration with fashion company InTheStyle, to release a collection of T-shirts, sweaters, hoodies and pyjamas featuring her viral quotes and memes. Following the success of the range, Collins collaborated with the company again in September, debuting her first plus-size collection with the brand which featured dresses, blouses and a selection of loungewear. During the COVID-19 pandemic, Collins released her own range of hand sanitizers and face masks. Following her weight loss, Collins began selling her old clothes on the online marketplace apps Depop and Vinted. In March 2021, Collins teamed up with The London Aesthetics Company to release GemmaCollagen, her own anti-ageing collagen supplement and skincare regime. Collins, who is regularly complimented on her skin, worked alongside the company's director Amrit Bhandal to create an ultimate skincare collection which included a cleanser, a toner, a day cream and a facial mask, as well as an eye serum and an amino acid night repair serum. The company also created a marine collagen supplement that included 90 capsules and was said to positively benefit the skin, hair, joints and muscles.
Sources: en.wikipedia.org
=== Removal of the smear layer and dentine etching === A dentine conditioning agent is used initially, to remove the smear layer resulting from the preparation of a cavity and, to alter the dentine surface by partially demineralising the intertubulary dentine. This partially demineralised dentine acts as a hollow scaffolding which can be perfused with the primer. Over-etching (as well as over-drying) of the dentine can lead to collapse of the collagen network, making infiltration of the primer more challenging. However, sclerosed dentine requires a longer time of exposure to the dentine conditioner compared to healthy dentine. Some dentine conditioners contain a chemical called glutaraldehyde, which reinforces the collagen matrix, preventing its collapse. Some common dentine conditioners include:
== Awards == German Innovation Award. Excellence in Business to Business – Pharmaceuticals, Winner 2019 German Innovation Award, Fortibone January 2020 Nutra Ingredients Awards. Ingredient of the Year: Healthy Ageing – Fortibone, GELITA – 2018, Winner 2018, January 2020 Life PR Award: German Innovation Award in gold for innovative detergent additive Novotec CB800, June 6, 2018 Nutraceuticals World: Top 100 Innovative Companies in Germany, Category "Innovative Processes" Cannes Corporate Media & TV Awards 2016: Four Dolphins for the company Video "You can see". Gold in category corporate videos and silver in the categories marketing films – B2B, information films and visitors films German Brand Award for successful brand management in the category "Industry Excellence in Branding", 2016 "Intermedia-globe Award" in gold, World Media Festival June 22, 2016 Frost & Sullivan Award, "European Health Ingredient of the Year" – 2008 New Hope, "GELITA Wins Frost & Sullivan Award European Health Ingredient of the Year 2008"
=== Sjögren's disease === Sjögren's disease is a long-term autoimmune disease that affects the body's moisture-producing glands (lacrimal and salivary), and often seriously affects other organ systems, such as the lungs, kidneys, and nervous system.
Bone is metabolically active tissue composed of several types of cells. These cells include osteoblasts, which are involved in the creation and mineralization of bone tissue, osteocytes, and osteoclasts, which are involved in the reabsorption of bone tissue. Osteoblasts and osteocytes are derived from osteoprogenitor cells, but osteoclasts are derived from the same cells that differentiate to form macrophages and monocytes. Within the marrow of the bone there are also hematopoietic stem cells. These cells give rise to other cells, including white blood cells, red blood cells, and platelets.
=== Appearance === Natural casing sausages are distinguishable from collagen or cellulose casings because of their irregularity, although high-quality sheep and lamb casings can be almost indistinguishable from a collagen casing as they have no noticeable imperfections. The main difference is in the way they are twisted and linked which affects the appearance of the final product and makes it easy to differentiate a hot dog using natural sheep or lamb casing vs collagen casing. The size and usage of natural casings relate to the animal from which they are derived, the narrowest being lamb followed by sheep followed by pig followed by beef. The size range for lamb is 14 mm to 28 mm in diameter (which is how casings are graded), the size range for sheep is 16 mm to 32 mm in diameter, the size range for pig is 28 mm to 58 mm in diameter, the size range for beef is 43 mm to 65 mm, although beef bung caps (which are not derived from the small intestine) have a size range of 115 mm to 130 mm.
Sources: en.wikipedia.org
Lyophilized products should be stored in airtight containers, protected from moisture and light, at the temperature specified by the manufacturer. Many require refrigeration at 2–8 °C, while some need frozen storage. Always check the product label for specific conditions.
Moisture can cause the porous cake to collapse, increase molecular mobility, and accelerate chemical degradation. It may also promote microbial growth if the product lacks preservatives. Proper sealing and handling are essential to maintain stability.
Some formulations contain labile biological molecules that degrade even in the dry state at higher temperatures. Others have a low glass transition temperature, meaning the cake can soften or collapse at room temperature. Cold storage reduces molecular motion and slows degradation.
Primary drying removes ice by sublimation under vacuum. Secondary drying removes water that is bound to the material, often by warming the product after most ice has left. Both stages occur below temperatures that would cause unwanted melting.